驾驶特性对进气道喷射汽油车RDE排放的影响*

doi:10.19562/j.chinasae.qcgc.2018.010.004

汽车工程 ›› 2018, Vol. 40 ›› Issue (10): 1146-1150.doi: 10.19562/j.chinasae.qcgc.2018.010.004

驾驶特性对进气道喷射汽油车RDE排放的影响^*

汪晓伟, 颜燕, 景晓军, 戴春蓓, 闫峰

中国汽车技术研究中心有限公司,天津 300300

出版日期:2018-10-25 发布日期:2018-10-25
通讯作者: 汪晓伟,工程师,博士研究生,E-mail:wangxiaowei@catarc.ac.cn。
基金资助:
*科技部大气污染成因控制技术专项(2016YFC0208002和2017YFC0212101)资助

Effect of Driving Pattern on RDE of Vehicle Equipped with a Port Fuel Injection Gasoline Engine

Wang Xiaowei, Yan Yan, Jing Xiaojun, Dai Chunbei, Yan Feng

China Automotive Technology and Research Center Co., Ltd., Tianjin 300300

Online:2018-10-25 Published:2018-10-25

摘要/Abstract

摘要： 使用便携式车载排放设备(PEMs)对一辆装有进气道喷射的自然吸气发动机的轻型汽油车按照轻型车国Ⅵ标准进行了真实驾驶排放(RDE)测试,并通过行程动力学定义了温和驾驶和激进驾驶。结果表明:激进驾驶的NO_x和PN排放跟温和驾驶相差不大。但在市区行程,激进驾驶的CO排放为温和驾驶CO排放的84倍。而对于总行程,激进驾驶的CO排放为温和驾驶CO排放的75倍。激进驾驶中频繁的加减速是CO排放大幅增加的主要原因。在市区行程,CO排放与加速度正相关;在高速行程,由于发动机运转在高速大负荷的工况点,而这些工况点在企业进行排放标定时往往被忽略,导致CO的排放很高。

关键词: 轻型车, 进气道喷射, 真实驾驶排放, 温和驾驶, 激进驾驶

Abstract: Real driving emission (RDE) tests are conducted by using a portable emission measurement system (PEMs) for a light duty gasoline vehicle equipped with a natural aspiration and port fuel injection (PFI) engine in accordance with China Ⅵ emission regulation of light-duty vehicles and moderate driving and dynamic driving are defined based on trip dynamics. Results show that NOx and PN emissions exhibit a small difference between dynamic driving and moderate driving, but the CO emission for dynamic driving is 84 times and 75 times of that for moderate driving in city trip and total trip respectively. Frequent acceleration and deceleration of dynamic driving is the major reason for drastic increase of CO emission. CO emission is proportional to the acceleration in the city trip. And the bad emission calibration for the high speed and high load condition may be responsible for the high CO emission in the motorway trip.

Key words: light-duty vehicle, port fuel injection, real driving emissions, moderate driving, dynamic driving

汪晓伟, 颜燕, 景晓军, 戴春蓓, 闫峰. 驾驶特性对进气道喷射汽油车RDE排放的影响^*[J]. 汽车工程, 2018, 40(10): 1146-1150.

Wang Xiaowei, Yan Yan, Jing Xiaojun, Dai Chunbei, Yan Feng. Effect of Driving Pattern on RDE of Vehicle Equipped with a Port Fuel Injection Gasoline Engine[J]. , 2018, 40(10): 1146-1150.

参考文献

[1] WEISS M, BONNEL P, HUMMEL R, et al. On-road emissions of light-duty vehicles in Europe[J]. Environ Sci Technol 2011,45:8575-8581.
[2] 张雄,李孟良,乔维高.汽车排放污染物测试的发展方向——车载排放测试[J].北京汽车,2006(6):34-39.
[3] VARELLA R A, DUARTE G, BAPTISTA P, et al. Comparison of data analysis methods for European real driving emissions regulation[C]. SAE Paper 2017-01-0997.
[4] 环境保护部.轻型汽车污染物排放限值和测量方法(中国第六阶段):GB18352.6—2016[S].2016.
[5] 付秉正,杨正军,尹航,等.轻型汽油车实际行驶污染物排放特性的研究[J].汽车工程,2017,39(4):376-380.
[6] 杨正军,付秉正,尹航,等.轻型柴油车实际行驶排放特性的研究[J].汽车工程,2017,39(5):497-502.
[7] MERKISZ J, PIELECHA J, BIELACZYC P, et al. Analysis of emission factors in RDE tests as well as in NEDC and WLTC chassis dynamometer tests[C]. SAE Paper 2016-01-0980.
[8] MAY J, BOSTEELS D, FAVRE C. An assessment of emissions from light-duty vehicles using PEMS and chassis dynamometer testing[C]. SAE Paper 2014-01-1581.
[9] ANDERSSON J, MAY J, FAVRE C, et al. On-road and chassis dynamometer evaluations of emissions from two Euro 6 diesel vehicles[C]. SAE Paper 2014-01-2826.
[10] PATHAK S K, SOOD V, SINGH Y, et al. Real world vehicle emissions: their correlation with driving parameters[J]. Transportation Research Part D,2016,44:157-176.
[11] GALLUS J, KIRCHNER U, VOGT R, et al. Impact of driving style and road grade on gaseous exhaust emissions of passenger vehicles measured by a portable emission measurement system (PEMS)[J]. Transportation Research Part D,2017,52:215-226.
[12] LEE T, PARK J, KWON S, et al. Variability in operation-based NO_x emission factors with different test routes, and its effects on the real-driving emissions of light diesel vehicles[J]. Science of The Total Environment,2013,461:377-385.
[13] DISCH C, PFEIL J, KUBACH H, et al. Experimental investigations of a DISI engine in transient operation with regard to particle and gaseous engine-out emissions[C]. SAE Paper 2015-01-1990.
[14] 刘巽俊.内燃机的排放与控制[M].北京:机械工业出版社,2005.
[15] 潘锁柱,宋崇林,裴毅强,等.缸内直喷汽油机颗粒物粒径分布特性[J].天津大学学报:自然科学与工程技术版,2013,46(7):629-634.

驾驶特性对进气道喷射汽油车RDE排放的影响^*

Effect of Driving Pattern on RDE of Vehicle Equipped with a Port Fuel Injection Gasoline Engine

PDF (PC)

赞

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 2

Metrics

本文评价

推荐阅读 10

[1]	谭丹,王亚超,谭建伟,李家琛,王昌钰,葛蕴珊. 不同环境温度下E10轻型车CO₂排放研究[J]. 汽车工程, 2023, 45(3): 451-458.
[2]	潘金冲, 华伦, 张文彬, 林延松, 张云龙. 润滑油灰分对直喷汽油车GPF性能影响的试验研究^*[J]. 汽车工程, 2019, 41(5): 487-492.