三火花塞点火系统对混动专用发动机稀燃性能影响试验研究

doi:10.19562/j.chinasae.qcgc.2023.11.015

Abstract

Abstract:

A study is conducted on a three-cylinder 1.5TGDI turbocharged direct injection engine， in terms of the effect of triple spark plug （TSP） ignition on the lean combustion performance. The results show that TSP can effectively extend the lean burn limit， with compression ratio of 15， the TSP can achieve stable combustion at lambda 1.95 for the specific operating condition of 2 000 r/min 8 bar BMEP， with the minimum brake specific fuel consumption （BSFC） reduced by 5 g/（kW·h） compared with that of the single spark plug， and raw NO _x emission reduced to about 50×10^-6. At this condition， the limit for a further lambda increase is mainly due to the boost capability. When the compression ration increases to 16， the minimum BSFC improvement is not obvious compared with that of the compression ratio of 15， and the lean burn limit decreases. The TSP has little benefit for reducing the knock tendency， but can increase the lean mixture combustion rate obviously， at the same lambda condition， its combustion duration can be 3-6°CA shortened compared to single spark plug， and increase by only 2°CA at lambda 1.95 compared to stoichiometric combustion. Through a further investigation on the potential maximum thermal efficiency， it shows that with the compression ratio of 15， the TSP can finally achieve 45.02% maximum brake thermal efficiency.

Key words: triple spark plug system, dedicated hybrid engine, homogeneous lean combustion, thermal efficiency, NO _x emission

Bowen Yan,Waters Benjamin,Pendlebury Ken,Tiegang Hu,Jiaxiang Zhang,Xiaoqian Yang,Yunping Pu. An Experimental Study on the Effect of Triple Spark Plug Ignition System on the Lean Combustion Performance of Dedicated Hybrid Engine[J].Automotive Engineering, 2023, 45(11): 2139-2147.

Figures/Tables 26

References 24

1	TATE E， HARPSTER M O， SAVAGIAN P. The electrification of the automobile： from conventional hybrid， to plug-in hybrids， to extended-range electric vehicles［J］. SAE International Journal of Passenger Cars Electronic & Electrical Systems， 2009， 1（1）： 156-166.
2	NAKATA K， SHIMIZU R. Toyota's new combustion technology for high engine thermal efficiency and high engine output performance［J］. Fortschritt-Berichte VDI， Reihe 12. Verkehrstechnik-Fahrzeugtechnik， 2016， Pt.2 TN.799： 1-17.
3	HAKARIYA M， TODA T， SAKAI M. The new toyota inline 4-cylinder 2.5L gasoline engine［C］. SAE Paper 2017-01-1021.
4	YAMAJI K， TOMIMATSU M， TAKAGI I， et al. New 2.0L I4 gasoline direct injection engine with Toyota new global architecture concept［C］. SAE Paper 2018-01-0370.
5	LEE B， OH H， HAN S， et al. Development of high efficiency gasoline engine with thermal efficiency over 42%［C］. SAE Paper 2017-01-2229.
6	ZHANG G Q， WANG Q， CHEN G， et al. Geely hybrid engine： world class efficiency for hybrid vehicles［C］. 29th Aachen Colloquium Sustainable Mobility， 2020： 65-95.
7	JUNG D， LEE B， SON J， et al. Development of GDI engine for improving brake thermal efficiency over 44%［C］. ASME 2019 Internal Combustion Engine Division Fall Technical Conference， 2019.
8	YAN B， YAO M F， MAO B， et al. A comparative study on the fuel economy improvement of a natural gas SI engine at the lean burn the and stoichiometric operation both with EGR under the premise of meeting EU6 emission legislation［C］. SAE Paper 2015-01-1958.
9	ADOMEIT P， SCHARF J， THEWES M， et al. Extreme lean gasoline technology - best efficiency and lowest emission powertrains［J］. Internationaler Motorenkongress 2017， 2017： 101-122.
10	SELLERS R， OSBORNE R， CAI W， et al. Designing and testing the next generation of high-efficiency gasoline engine achieving 45% brake thermal efficiency［C］. 28th Aachen Colloquium Automobile and Engine Technology， 2019： 1129-1143.
11	BRANNYS S， SC M， GEHRKE I S， et al. Maximum efficiency concept of a 1.5l TSI evo for future hybrid powertrains［C］. 28th Aachen Colloquium Automobile and Engine Technology， 2019： 99-120.
12	BUNCE M， BLAXILL H， COOPER A. Development of both active and passive pre-chamber jet ignition multi-cylinder demonstrator engines［C］. 28th Aachen Colloquium Automobile and Engine Technology， 2019： 907-941.
13	ATTARD W P， BLAXILL H. A lean burn gasoline fueled pre-chamber jet ignition combustion system achieving high efficiency and low NOx at part load［C］. SAE Paper 2012-01-1146.
14	FORTE C， BIANCHI G M， CORTI E， et al. Evaluation of the effects of a twin spark ignition system on combustion stability of a high performance PFI engine［J］. Energy Procedia， 2015， 81： 897-906.
15	BAILKERI N， PRASAD K， RAO S. Performance study on twin plug spark ignition engine at different ignition timings［J］. International Journal of Science & Research， 2013， 2（8）： 231-236.
16	SELLNAU M， CHO K， ZHANG Y. Pathway to 50% brake thermal efficiency using gasoline direct injection compression ignition （GDCI）［C］. 28th Aachen Colloquium Automobile and Engine Technology， 2019： 1145-71.
17	YANG B， WANG H， YAO M F， et al. Experimental investigation on the effects of injection strategy on combustion and emission in a heavy-duty diesel engine fueled with gasoline［C］. SAE Paper 2017-01-2266.
18	NAKAI E， GOTO T， EZUMI K， et al. Mazda SKYACTIV-X 2.0L gasoline engine［C］. 28th Aachen Colloquium Automobile and Engine Technology， 2019： 55-78.
19	NAGASAWA T， OKURA Y， YAMADA R， et al. Thermal efficiency improvement of super-lean burn spark ignition engine by stratified water insulation on piston top surface［J］. International Journal of Engine Research， 2021， 22（5）： 1421-1439.
20	NAKATA K， NOGAWA S， TAKAHASHI D. Engine technologies for achieving 45% thermal efficiency of S.I. engine［C］. SAE Paper 2015-01-1896.
21	DUBEY A， PARETA A， SHARMA P. Study of multiple spark ignition engines with single spark ignition engines on the basis of engine efficiency and emission characteristics size［J］. International Journal of Current Engineering and Technology， 2014， 3： 14-17.
22	MATSUURA K. Measurements of flame propagation in a rotary engine using rotor-installed ionization gaps［J］. Transactions of the JSME， 2019， 85（869）： 18-00312.
23	闫博文，马天宇，蒲运平，等. 混动发动机在不同水温下的喷油控制策略影响试验研究［J］. 汽车工程， 2022， 44（9）： 1394-1399.
	YAN B W， MA T Y， PU Y P， et al. Experimental study on the effect of fuel injection control strategy under different coolant temperatures for a hybrid engine［J］. Automotive Engineering， 2022， 44（9）： 1394-1399.
24	KUKKADAPU G， KUMAR K， SUNG C， et al. Autoignition of gasoline and its surrogates in a rapid compression machine Engine Technologies［J］. Proceedings of the Combustion Institute， 2013， 34： 345-352.

项目	参数
发动机型式	直列3缸，增压直喷
缸径×行程	76 mm×110 mm
冲程/缸径比	1.45
排量	1.496 L
压缩比	14-16
配气机构	DVVT
最高燃油喷射压力	35 MPa
汽油低热值	42.5 MJ/kg
汽油辛烷值	RON 92
最大转矩	167 N·m@2 500-3 900 r/min
额定功率	70 kW@4 000 r/min
机油型号	0W16#
冷却水供给	电子主水泵

项目	参数
运行工况	2 000 r/min、8 bar BMEP & 最高热效率工况点
压缩比	15&16
点火系统	单火花塞&三火花塞
过量空气系数lambda	1.0~2.0
DVVT调整范围	60°CA
喷油相位	-290°CA ATDC
喷油压力	35 MPa
燃烧循环波动边界	3%
燃烧相位CA50最优目标	7~9°CA ATDC
正常环境中冷后进气温度	35 °C（特征工况点、最高热效率工况点）
低温环境中冷后进气温度	15~18 °C（最高热效率工况点）
水温	90 °C
机油温度	90 °C

测试参数	测试设备	测试精度
转速	AVL DYNOFORCE ASM 600	±1
转矩	AVL DYNOFORCE ASM 600	±0.3
燃油流量	FuelExact PLU 740	±0.1%
过量空气系数	ES621+LSU4.9	±2%
缸内压力	Kisler 6115	±1%
气体排放	HORIBA MEXA-7100 DEGR	0-10%LR：±0.2%LR 10%LR-50%FS：2.0% 50%-100%FS：±1%FS

[1]	Liqun Lyu, Long Xu, Hang Yin, Yang Yang, Yunshan Ge. Research on Real-World NO _x Emission Analysis Methods for Heavy-Duty Diesel Vehicles [J]. Automotive Engineering, 2024, 46(1): 151-160.
[2]	Shenglong Xu,Jun Song,Wei Yuan. Research on NO _x Emission Control Method of Real Driving Based on Durable Aging Vehicle [J]. Automotive Engineering, 2023, 45(4): 663-671.
[3]	Yabin Cui,Haipeng Lai,Nan Jia,Maobin Liu,Zhongying Yuan. Development of Lean Burn Engine with High Thermal Efficiency [J]. Automotive Engineering, 2023, 45(3): 430-437.
[4]	Bowen Yan,Tianyu Ma,Yunping Pu,Tiegang Hu,Wei Deng,Ping Jiang,Xianghong Nie. Experimental Study on the Effect of Fuel Injection Control Strategy Under Different Coolant Temperatures for a Hybrid Engine [J]. Automotive Engineering, 2022, 44(9): 1394-1399.
[5]	Miao Yang,Xuedong Lin,Degang Li,Yingshu Liu. Effect of Air Flow Conditions in Cylinder and Double-Point Ignition on Flame Propagation Characteristics and Thermal Efficiency of CNG Engine [J]. Automotive Engineering, 2022, 44(1): 52-57.
[6]	Feng Hao, Qin Bo, Lin Sicong ,Sun Yunlong. An Experimental Study on the Effect of Electric Supercharger on the Performance of a Turbocharged Miller Cycle Gasoline Engine [J]. Automotive Engineering, 2019, 41(7): 738-743.

An Experimental Study on the Effect of Triple Spark Plug Ignition System on the Lean Combustion Performance of Dedicated Hybrid Engine

RichHTML

PDF (PC)

Like

Knowledge

Abstract

Cite this article

share this article

Figures/Tables 26

References 24

Related Articles 6

Metrics

Comments

Recommended 10