基于离子电流与缸压信息融合的HCCI发动机不完全燃烧提前诊断*

doi:10.19562/j.chinasae.qcgc.2020.10.007

汽车工程 ›› 2020, Vol. 42 ›› Issue (10): 1340-1345.doi: 10.19562/j.chinasae.qcgc.2020.10.007

基于离子电流与缸压信息融合的HCCI发动机不完全燃烧提前诊断^*

王硕¹, 朱登豪¹, 邓俊¹, 李理光^1,2

1.同济大学汽车学院,上海 201804;
2.同济大学中德学院,上海 201804

收稿日期:2020-07-24 修回日期:2020-08-29 出版日期:2020-10-25 发布日期:2020-10-26
通讯作者: 邓俊,副教授,博士,E-mail:eagledeng@tongji.edu.cn。
基金资助:
* 国家自然科学基金(51761135105,52076153)资助。

Advanced Diagnosis of Incomplete Combustion in HCCI Engine Based on Information Fusion of Ion Current and Cylinder Pressure

Wang Shuo¹, Zhu Denghao¹, Deng Jun¹, Li Liguang^1,2

1. School of Automotive Studies, Tongji University, Shanghai 201804;
2. Chinesisch-Deutsches Hochschulkolleg, Tongji University, Shanghai 201804

Received:2020-07-24 Revised:2020-08-29 Online:2020-10-25 Published:2020-10-26

摘要/Abstract

摘要： 由于随机出现的非正常燃烧现象,均质压燃(HCCI)发动机的应用受到阻碍。本文中以一台压缩比及配气系统经过改造的2.0 L四缸发动机为平台,以负阀重叠期的缸压和离子电流为信号,研究了HCCI发动机的不完全燃烧提前诊断方法。结果表明:负阀重叠期缸压峰值相位与离子电流峰值可作为不完全燃烧的诊断依据;单独使用缸压峰值相位或离子电流峰值进行诊断时,大部分不完全燃烧循环可被提前判断,诊断灵敏度分别可达93.8%和95.6%,但部分正常循环会被误判为不完全燃烧循环。使用缸压和离子电流信号相结合进行诊断时,可大幅提高诊断准确率至90.0%,同时诊断灵敏度保持为91.4%。

关键词: HCCI, 提前诊断, 信号融合, 缸压, 离子电流

Abstract: Due to the random abnormal combustion, the application of HCCI engine is hindered. In this paper, based on the platform of a 2.0 L four-cylinder engine with modified compression ratio and valve mechanism, taking the cylinder pressure and ion current in the period of negative valve overlap as signals, the method of advanced diagnosis of incomplete combustion in HCCI engine is studied. The results show that the peak phase of cylinder pressure and the peak value of ion current during NVO can be used as the basis for incomplete combustion diagnosis. When the peak phase of cylinder pressure or the peak value of ion current is used alone for diagnosis, most of the incomplete combustion cycles can be judged in advance, with the diagnostic sensitivity of 93.8% and 95.6% respectively; but some of the normal cycles can be misjudged as incomplete combustion cycles. When using the combination of cylinder pressure and ion current signal for diagnosis, the diagnostic accuracy can be greatly improved to 90.0%, and the diagnostic sensitivity can be kept at 91.4%

Key words: HCCI, advanced diagnosis, information fusion, cylinder pressure, ion current

王硕, 朱登豪, 邓俊, 李理光. 基于离子电流与缸压信息融合的HCCI发动机不完全燃烧提前诊断^*[J]. 汽车工程, 2020, 42(10): 1340-1345.

Wang Shuo, Zhu Denghao, Deng Jun, Li Liguang. Advanced Diagnosis of Incomplete Combustion in HCCI Engine Based on Information Fusion of Ion Current and Cylinder Pressure[J]. Automotive Engineering, 2020, 42(10): 1340-1345.

参考文献

[1] ONISHI S,JO S H,SHODA K,et al. Active thermo-atmosphere combustion (ATAC)-a new combustion process for internal combustion engines [C]. SAE Paper 790501.
[2] NOGUCHI M,TANAKA Y,TANAKA T,et al. A study on gasoline engine combustion by observation of intermediate reactive products during combustion [C]. SAE Paper 790840.
[3] THRING R H. Homogeneous charge compression-ignition (HCCI) engines [C]. SAE Paper 892068.
[4] YU H,SU W H. Numerical study on a high efficiency gasoline reformed molecule HCCI combustion using exergy analysis [C]. SAE Paper 2017-01-0735.
[5] DEC J E,YANG Y. Boosted HCCI for high power without engine knock and with ultra-low NO_x emissions-using conventional gasoline[J]. SAE Int. J. Engines ,3(1):750-767.
[6] CHEN T,XIE H,LI L,et al. Expanding the low load limit of hcci combustion process using EIVO strategy in a 4VVAS gasoline engine [C]. SAE Paper 2012-01-1121.
[7] AROONSRISOPON T,WERNER P,WALDMAN J O,et al. Expanding the HCCI operation with the charge stratification [C]. SAE Paper 2004-01-1756.
[8] MILOVANOVIC N,BLUNDELL D,PEARSON R,et al. Enlarging the operational range of a gasoline CAI engine by controlling the coolant temperature [C]. SAE Paper 2005-01-0157.
[9] WILHELMSSON C,VRESSNEr A,TUNESTAL P,et al. Com-bustion chamber wall temperature measurement and modeling during transient CAI operation [C]. SAE Paper 2005-01-3731.
[10] THIROUARD B,CHEREL J. Nature of CAI combustion and air/fuel ratio stratification effects [J]. Oil & Gas Science and Technology,2006,61 (1): 95-119.
[11] GLEWEN W J,WAGNER R M,EDWARDS K D,et al. Analysis of cyclic variability in spark-assisted HCCI combustion using a double Wiebe function [J]. Proceedings of the Combustion Institute, 2009,32 (2) :2885-2892.
[12] LEHRHEUER B, PISCHINGER S,WICK M,et al. A study on in-cycle combustion control for gasoline controlled autoignition [C]. SAE Paper 2016-01-0754.
[13] ANDERT J, WICK M, LEHRHEUER B, et al. Autoregressive modeling of cycle-to-cycle correlations in homogeneous charge compression ignition combustion [J]. International Journal of Energy Research,2018, 19 (7) :790-802.
[14] 张宏超. 基于振动信号及飞轮转速信号相耦合的HCCI汽油机燃烧反馈控制研究[D]. 天津:天津大学,2012.
ZHANG H C. Research on HCCI combustion feedback control with knock sensor and flywheel speed[D]. Tianjin:University of Tianjin, 2012.
[15] GUILLEMIN F,GRONDIN O,CHAUVIN J,et al. Combustion parameters estimation based on knock sensor for control purpose using dedicated signal processing platform[C]. SAE Paper 2008-01-0790.
[16] 方成. 基于缸压信息的压燃发动机燃烧模式识别与反馈控制研究[D]. 北京:清华大学,2015.
FANG C. Combustion pattern recognition and feedback control based on cylinder pressure information for CI engines[D]. Beijing: University of Tsinghua, 2015.
[17] SU R N,THOMAS R P,TANG X G. Transient control of HCCI engines using MRPR or its proxies [C]. SAE Paper 2012-01-1580.
[18] NICOLO C,NAHUEL R,LUCA P,et al. Investigation on pre-ignition combustion events and development of diagnostic solutions based on ion current signals [J]. SAE Int. J. Engines,2017,10 (4):1518-1523.
[19] LIU Y T,DENG J,HU Z J,et al. In-cycle combustion feedback control for abnormal combustion based on digital ion current signal [J]. International Journal of Energy Research,2018,19 (2) :241-249.
[20] CHAO Y D,CHEN X,DENG J,et al. Additional injection timing effects on first cycle during gasoline engine cold start based on ion current detection system [J]. Appl. Energy,2018, 221:55-66.
[21] 张栖玉,张志永,李从跃,等. 基于离子电流积分信号的HCCI失火控制[J]. 汽车工程,2011,33(10):850-854.
ZHANG Q Y,ZHANG Z Y,LI C Y,et al. HCCI misfire control based on ion current integral signal[J]. Automotive Engineering,2011,33(10):850-854.
[22] 张志永,李从跃,曹银波,等. 基于离子电流反馈的失火循环内补火控制实验[J]. 内燃机学报,2012,30(1):56-61.
ZHANG Z Y,LI C Y,CAO Y B,et al. An experimental study of re-spark ignition control in misfired combustion cycle based on ion current feedback[J]. Transactions of CSICE,2012,30(1):56-61.
[23] 李超,陆海峰,张光攀,等. 改进型离子电流检测系统在汽油机爆震检测中的应用研究[J]. 汽车工程,2016,38(10):1258- 1263.
LI C,LU H F,ZHANG G P,et al. The applications of a modified ion current detecting system to the detection of gasoline engine detonation[J]. Automotive Engineering,2016,38(10):1258-1263.
[24] FLIERL R,GOLLASCH D, KNECHT A,et al. Improvements to a four cylinder gasoline engine through the fully variable valve lift and timing system UniValve®[C]. SAE Paper 2006-01-0223.

基于离子电流与缸压信息融合的HCCI发动机不完全燃烧提前诊断^*

Advanced Diagnosis of Incomplete Combustion in HCCI Engine Based on Information Fusion of Ion Current and Cylinder Pressure

PDF (PC)

赞

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 3

Metrics

本文评价

推荐阅读 10

[1]	曲俊龙,史文库,陈志勇. 汽车传动系扭振激励辨识与减振措施[J]. 汽车工程, 2022, 44(2): 264-271.
[2]	谢丽萍,卢炽华,刘志恩,朱亚伟,刘恺,孙唯,吕之品. 基于缸压信号的汽车声音合成算法研究[J]. 汽车工程, 2021, 43(10): 1549-1554.
[3]	曾小华, 钱琦峰, 宋大凤, 谷京哲, 苑卫松. 基于加速度校正的坡度估计算法与实现^*[J]. 汽车工程, 2020, 42(10): 1369-1377.