加载位置对Hybrid Ⅲ假人胸部响应影响

doi:10.19562/j.chinasae.qcgc.2021.01.013

汽车工程 ›› 2021, Vol. 43 ›› Issue (1): 99-104.doi: 10.19562/j.chinasae.qcgc.2021.01.013

加载位置对Hybrid Ⅲ假人胸部响应影响

马伟杰¹,刘志新¹,程翔宇²,蒋彬辉²()

^1.中国汽车技术研究中心有限公司，天津 300300
^2.湖南大学，汽车车身先进设计制造国家重点实验室，长沙 410082

收稿日期:2020-05-07 出版日期:2021-01-25 发布日期:2021-02-03
通讯作者: 蒋彬辉 E-mail:jjhhzz123@163.com
基金资助:
国家自然科学基金(5162100);中国汽车技术研究中心重点项目(14150125)

Effects of Loading Position on Thoracic Responses of Hybrid Ⅲ Dummy

Weijie Ma¹,Zhixin Liu¹,Xiangyu Cheng²,Binhui Jiang²()

^1.China Automotive Technology and Research Center Co. ，Ltd. ，Tianjin 300300
^2.Hunan University，State Key Laboratory of Advanced Design and Manufacturing for Vehicle Body，Changsha 410082

Received:2020-05-07 Online:2021-01-25 Published:2021-02-03
Contact: Binhui Jiang E-mail:jjhhzz123@163.com

摘要/Abstract

摘要：

在世界各国汽车安全碰撞法规和NCAP试验中，大多都会采用Hybrid Ⅲ假人的胸部最大压缩量来评估车辆对乘员胸部的防护效果。但因Hybrid Ⅲ假人的胸部最大压缩量采用定点测量办法，使测量结果易受加载位置的影响。针对该问题，本文通过假人胸部低速冲击标定试验，研究了加载位置对Hybrid Ⅲ假人胸部压缩量的影响。结果表明，Hybrid Ⅲ 50^th男性假人的最大胸部压缩变形与摆锤撞击中心在Z方向的偏移量呈线性（R²=0.9554）负相关性。Hybrid Ⅲ 5^th女性假人由于乳房的影响，虽然加载位置对胸部最大压缩变形仍然有较大的影响，但胸部最大压缩变形与冲击加载位置的相关性不如男性假人那么明显。最后利用标定试验中获得的Hybrid Ⅲ 50^th男性假人的最大胸部压缩变形与摆锤撞击中心位置的相关性方程对同一车型的两个不同安全带佩戴位置的假人胸部最大压缩变形进行了修正。

关键词: 车辆安全, 碰撞试验, 摆锤冲击, 安全带佩戴位置, 胸部压缩量, Hybrid Ⅲ假人

Abstract:

The national automotive safety regulations and new car assessment program（NCAP） tests in most countries in the world use the maximum chest compression of Hybrid Ⅲ dummy to evaluate the protective effect of vehicle on occupant's thorax. However， the maximum chest compression of the Hybrid Ⅲ dummy's thorax is measured at a fix point， so the measurement results are easily affected by loading position. In view of the problem， the effects of loading position on Hybrid Ⅲ dummy's chest compression are studied through the low?speed impact calibration test of dummy's thorax in this paper. The results indicate that the maximum chest compression of Hybrid Ⅲ 50^th male dummy is linearly negatively correlated（R² = 0.9554） with the deviation in the Z direction from the pendulum impact center specified in regulation. For Hybrid Ⅲ 5^th female dummy，though the impact position still has significant effects on the maximum compression of chest， but due to the effects of breast，the correlation between the maximum chest compression of female dummy's thorax and impact position is not as apparent as that of male dummy. Finally， the correlation formula between the maximum chest compression of Hybrid Ⅲ 50^th male dummy and impact position obtained in calibration test is used to correct the maximum compression of the dummy's thorax in real vehicle crash tests with two different seat belt wearing positions.

Key words: vehicle safety, crash test, pendulum impact, seat belt wearing position, chest compression, Hybrid Ⅲ dummy

马伟杰,刘志新,程翔宇,蒋彬辉. 加载位置对Hybrid Ⅲ假人胸部响应影响[J]. 汽车工程, 2021, 43(1): 99-104.

Weijie Ma,Zhixin Liu,Xiangyu Cheng,Binhui Jiang. Effects of Loading Position on Thoracic Responses of Hybrid Ⅲ Dummy[J]. Automotive Engineering, 2021, 43(1): 99-104.

图/表 12

图1

图2

图3

图4

表1

图5

图6

表2

图7

表3

图8

图9

参考文献 11

1	HU J， KLINICH K D. Toward designing pedes⁃trian⁃friendly vehicles［R］. Michigan：The University of Michigan Transportation Research Institute， 2012.
2	HORSCH J D， MELVIN J W， VIANO D C， et al. Thoracic injury assessment of belt restraint systems based on Hybrid Ⅲ chest compression［C］. SAE Paper912895.
3	PEREIRA R， TANK M. Study of parameters influencing the chest deflection of hybrid Ⅲ dummy in crash tests［C］. SAE Paper 2012-28-0002.
4	HAIGHT S， SAMAHA R R， BISS D. Analysis of seat belt positioning in recent NCAP crash tests［C］. SAE Paper 2013-01-0460.
5	Australasian new car assessment program（A-NCAP Ver5.0）［S］. Australia：Australasian Automobile Association， 2011.
6	Code of Federal Regulations. Title 49 part 572-anthropomorphic test devices［S］. Washington DC： National Highway Traffic Safety Administration， 2011.
7	Low speed thorax impact test procedure for the HⅢ50 male dummy［S］. Michigan：SAE International， 2015.
8	Low speed thorax impact test procedure for the HⅢ5 F dummy［S］. Michigan： SAE International， 2016.
9	王凯，马伟杰. Hybrid Ⅲ50百分位正碰假人胸部肋骨特性研究［C］. 2012中国汽车安全技术国际研讨会论文集， 2012.
	WANG K， MA W J. Research on the characteristic of hybrid Ⅲ 50th dummy's ribs［C］. Proceedings of 2012 China International Symposium on Automotive Safety Technology， 2012.
10	Hybrid Ⅲ 50th percentile male， parts list and drawings subpart E［S］. Washington， DC：National Highway Traffic Safety Administration （NHTSA）， 1997.
11	中国新车评价规程［S］. 天津：中国汽车技术研究中心有限公司，2018.
	China new car assessment profram［S］. Tianjin：China Automotive Technology and Research Center Co.， Ltd.， 2018.

Z/mm	F/kN	v/ (m·s^-1)	D/mm
0	2.58	3.00	25.0
20	2.56	2.99	24.6
40	2.55	3.02	24.2
60	2.50	3.00	23.9
80	2.43	3.01	23.0

组别	α /(°)	F/kN	v/(m·s^-1)	D/mm
1	16	1.93	3.05	20.2
2	21	1.94	3.05	20.6
3	26	1.95	3.04	20.7
4	31	1.97	3.04	20.5
5	36	2.00	3.04	20.6

组别	Z/mm	F/kN	v/(m·s^-1)	D/mm
P0	0	1.97	3.03	19.9
P20	20	1.89	2.92	19.4
P40	40	1.90	3.05	19.8
P60	60	1.89	3.05	19.5
P80	80	1.83	3.04	18.5

[1]	阮世捷,苏航杰,李海岩,崔世海,贺丽娟,吕文乐. 正面100%重叠刚性壁障碰撞试验仿真中三岁儿童乘员的损伤评价[J]. 汽车工程, 2022, 44(3): 403-411.
[2]	武和全, 彭金平, 邓晓顺, 金鑫, 胡林. 正面碰撞中的老年驾驶员胸部响应研究^*[J]. 汽车工程, 2020, 42(8): 1050-1059.
[3]	贺宜, Xiao-Yun LU, 褚端峰, 吴超仲. 车路环境耦合作用下侧向动力学模型可靠性估计[J]. 汽车工程, 2019, 41(7): 800-806.
[4]	宋志强, 曹立波, 陈龙, 张建强. 一种新型碰撞试验装置及其控制系统的研发^*[J]. 汽车工程, 2019, 41(1): 42-49.

加载位置对Hybrid Ⅲ假人胸部响应影响

Effects of Loading Position on Thoracic Responses of Hybrid Ⅲ Dummy

RichHTML

PDF (PC)

赞

可视化

摘要/Abstract

引用本文

使用本文

图/表 12

参考文献 11

相关文章 4

Metrics

本文评价

推荐阅读 10