添加乙醇燃料对汽油机起动过程微粒排放的影响*

doi:10.19562/j.chinasae.qcgc.2018.012.003

汽车工程 ›› 2018, Vol. 40 ›› Issue (12): 1393-1397.doi: 10.19562/j.chinasae.qcgc.2018.012.003

添加乙醇燃料对汽油机起动过程微粒排放的影响^*

袁超^1,3, 洪伟^1,2, 苏岩^1,2, 解方喜^1,2, 陈静⁴

1.吉林大学,汽车仿真与控制国家重点实验室,长春 130025;
2.吉林大学汽车工程学院,长春 130025;
3.一汽铸造有限公司,长春 130062;
4.江西五十铃发动机有限公司,南昌 330100

收稿日期:2017-10-11 出版日期:2018-12-25 发布日期:2018-12-25
通讯作者: 苏岩,副教授,博士,E-mail:suyan@jlu.edu.cn
基金资助:
国家自然科学基金(51276080)和吉林省科技发展计划项目(20170101131JC)资助

Influence of Ethanol-gasoline Blended Fuels on Gasoline Engine Particulate Emission During Start

Yuan Chao^1,3, Hong Wei^1,2, Su Yan^1,2, Xie Fangxi^1,2, Chen Jing⁴

1.Jilin University, State Key Laboratory of Automotive Simulation and Control, Changchun 130025;
2.College of Automotive Engineering, Jilin University, Changchun 130025;
3.FAW Foundry Co., Ltd., Changchun 130062;
4.Jiangxi Isuzu Motors Co., Ltd., Nanchang 330100

Received:2017-10-11 Online:2018-12-25 Published:2018-12-25

摘要/Abstract

摘要： 为研究乙醇燃料的添加对直喷汽油机起动过程中微粒排放的影响,通过在汽油中添加体积百分比为10%和20%的乙醇得到E10和E20燃料,采用这两种燃料和汽油燃料对直喷汽油机起动过程的微粒排放进行了研究。结果表明:在起动前10s初始阶段,不论燃用哪一种燃料,排气中微粒数量浓度都会急剧增加,是核态和积聚态两种形态微粒共同作用的结果,而起动过程中微粒数量浓度排放始终以核态为主;随着冷却液温度升高,积聚态微粒数量会大幅度降低;汽油中添加一定数量的乙醇,可以改善在起动工况下的核态微粒排放;燃用E20燃料在20和80℃条件下起动40s内微粒数量总浓度分别降低了37.8%和64.5%。

关键词: 直喷汽油机, 乙醇, 微粒, 起动, 排放

Abstract: In order to investigate the effect of ethanol addition on gasoline direct injection engine particulate emission during the starting period, E10 and E20 fuels are obtained by blending 10% and 20% volume fraction ethanol fuel into gasoline. With the two fuels and gasoline fuel, study of particulate emission from GDI engine during the starting period is conducted. It is found that particle number concentration increases dramatically during the first 10 seconds of the initial starting period with each fuel, which is due to increase of both nuclear mode and accumulated mode particles. The particulate emission is dominated by nuclear mode particles. As the temperature of the coolant increases, the amount of accumulated particles decreases dramatically. Adding a certain amount of ethanol to gasoline can improve the emission of nuclear mode particles under the start condition. The total concentration of particulates reduces by 37.8% and 64.5% during 40s starting period respectively, at 20 and 80℃ with E20 fuel.

Key words: gasoline direct injection engine, ethanol, particulate, start, emission

袁超, 洪伟, 苏岩, 解方喜, 陈静. 添加乙醇燃料对汽油机起动过程微粒排放的影响^*[J]. 汽车工程, 2018, 40(12): 1393-1397.

Yuan Chao, Hong Wei, Su Yan, Xie Fangxi, Chen Jing. Influence of Ethanol-gasoline Blended Fuels on Gasoline Engine Particulate Emission During Start[J]. , 2018, 40(12): 1393-1397.

参考文献

[1] GAUDERMAN W J, URMAN R, AVOL E, et al. Association of improved air quality with lung development in children[J]. New England Journal of Medicine,2015,372(10):905-913.
[2] BRAISHER M, STONE R, PRICE P. Particle number emissions from a range of European vehicles[C]. SAE Paper 2010-01-0786.
[3] 裴毅强,张淼,秦静,等.喷油定时对汽油机燃烧和微粒排放的影响及优化[J].哈尔滨工程大学学报,2015,36(7):927-931.
[4] 黄雅卿,王志,王建昕.喷油时刻对缸内直喷汽油机颗粒物排放的影响[J].内燃机学报,2014,32(5):420-425.
[5] PECKHAM M S, FINCH A, CAMPBELL B, et al. Study of particle number emissions from a turbocharged gasoline direct injection(GDI) engine including data from a fast-response particle size spectrometer[C]. SAE Paper 2011-01-1224.
[6] WHELAN I, SMITHW, TIMONEY D, et al. The effect of engine operating conditions on engine-out particulate matter from a gasoline direct-injection engine during cold-start[C]. SAE Paper 2012-01-1711.
[7] 钟兵,洪伟,苏岩,等.点火时刻对怠速工况缸内直喷汽油机微粒排放特性的影响[J].西安交通大学学报,2015,49(3):32-37.
[8] CHEN L F, BRAISHER M, CROSSLEY A, et al. The influence of ethanol blends on particulate matter emissions from gasoline direct injection engines[C]. SAE Paper 2010-01-0793.
[9] LIANG B, GE Y S, TAN J W, et al. Comparison of PM emissions from a gasoline direct injected (GDI) vehicle and a port fuel injected (PFI) vehicle measured by electrical low pressure impactor (ELPI) with two fuels: gasoline and M15 methanol gasoline[J]. Journal of Aerosol Science,2013,57:22-31.
[10] 李翔,裴毅强,秦静,等.GDI发动机燃用甲醇及甲醇/汽油混合燃料的微粒排放特性研究[J].内燃机工程,2015,36(2):1-6.
[11] KITTLESON D B. Engines and nano-particles: a review[J]. Journal of Aerosol Science,1998,29:575-588.

[1]	吕立群, 徐龙, 尹航, 杨杨, 葛蕴珊. 重型柴油车实际道路NO _x 排放分析方法研究[J]. 汽车工程, 2024, 46(1): 151-160.
[2]	李晓娜,解方喜,窦慧莉,刘江唯,刘宇. 气门重叠角对GDI发动机性能和微粒排放的影响[J]. 汽车工程, 2023, 45(4): 654-662.
[3]	徐胜龙,宋军,袁伟. 基于耐久老化车辆的实际道路行驶NO _x 排放控制方法研究[J]. 汽车工程, 2023, 45(4): 663-671.
[4]	谭丹,王亚超,谭建伟,李家琛,王昌钰,葛蕴珊. 不同环境温度下E10轻型车CO₂排放研究[J]. 汽车工程, 2023, 45(3): 451-458.
[5]	闫博文,Waters Benjamin,Pendlebury Ken,胡铁刚,张家祥,杨晓前,蒲运平. 三火花塞点火系统对混动专用发动机稀燃性能影响试验研究[J]. 汽车工程, 2023, 45(11): 2139-2147.
[6]	闫博文,马天宇,蒲运平,胡铁刚,邓伟,蒋平,聂相虹. 混动发动机在不同水温下的喷油控制策略影响试验研究[J]. 汽车工程, 2022, 44(9): 1394-1399.
[7]	王俊,申立中,毕玉华,雷基林. 不同海拔下基于VNT驱动的EGR对轻型柴油机燃烧与排放的影响[J]. 汽车工程, 2022, 44(7): 1088-1097.
[8]	张立军,高泽,余海燕. 基于全生命周期分析的白车身选材方法[J]. 汽车工程, 2022, 44(6): 945-952.
[9]	解方喜,孟祥龙,刘宇,李晓娜,张玉林,冯海洲. EVCT对直喷汽油机燃烧和微粒排放的影响[J]. 汽车工程, 2022, 44(5): 701-708.
[10]	詹炜鹏,王震坡,邓钧君,刘鹏,崔丁松,李海涛. 基于大数据的电动汽车行驶阶段碳减排影响因素分析[J]. 汽车工程, 2022, 44(10): 1581-1590.
[11]	蒋晓寒,谭建伟,徐长建,葛蕴珊,郝利君,王欣,李家琛. 基于粒径分布的直喷汽油车颗粒物排放特性研究[J]. 汽车工程, 2022, 44(10): 1609-1618.
[12]	汪晓伟,景晓军,高涛,谷雪景,张佑源,吴琳琳. 基于发动机在环的重型柴油车实际道路细小颗粒物排放特性研究[J]. 汽车工程, 2022, 44(1): 58-63.
[13]	施佳叶,王金秋,邓俊,缪新轲,刘逸晖,李理光. 基于两级高能点火和被动预燃室的高压缩比汽油机燃烧及排放特性研究[J]. 汽车工程, 2021, 43(9): 1300-1307.
[14]	陈贵升,魏峰,肖仁鑫,张敬贤,王震江,张涵. 预喷策略耦合EGR对DN双燃料发动机工作过程的影响[J]. 汽车工程, 2021, 43(8): 1143-1151.
[15]	王长卉,刘泽民,李雁飞,帅石金,邵慧芳,王银辉. 电量保持阶段增程器的排放与工作特性的试验研究[J]. 汽车工程, 2021, 43(5): 667-674.

添加乙醇燃料对汽油机起动过程微粒排放的影响^*

Influence of Ethanol-gasoline Blended Fuels on Gasoline Engine Particulate Emission During Start

PDF (PC)

赞

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

Metrics

本文评价

推荐阅读 10